Urtubia Urbina, Alejandra Pamela

The analysis of Cu distribution in pre-treated mine tailings after electrodialytic remediation was carried out by using two methods of sequential extraction. The initial content of copper in the tailings was 1109 mg Cu/kg of dry tailing, where close to 40% of the sample in weight corresponded to a soluble fraction. The tailing was treated with a leaching solution for 24 h. Three different solutions were tested: H2SO4 + HNO3 with pH = 1.9; H2SO4 + HNO3 with pH = 4.2; and NH4Cl 0.8 mol/L with pH = 5.5. After that, electrodialytic remediation experiments were carried out using an electric field of 2.7 V/cm for 15 days. The best performance for the complete cell was obtained with H2SO4 + HNO3 solutions, with a copper removal efficiency in the range of 62% to 67% and a current efficiency between 6% and 9%. The results of the remaining copper concentration between anode and cathode, from both procedures of sequential extraction, showed similar trends. The differences were mainly attributed to the use of different extractant solutions and extraction times. Soluble and exchangeable fractions were easily removed, with efficiencies higher than 80%. The lowest copper removal efficiency was obtained with NH4Cl 0.8 mol/L.

Grapes are a source of native yeasts and lactic acid bacteria (LAB); however, the microbial make up is dependent on the grape cultivar and the regional growth conditions. Therefore, the aim of this study was to characterize the yeast and LAB in seven grape cultivars cultivated in Chile. Grape juices were fermented at 25 °C for 7 days. Samples were collected to analyze sugar, organic acids, and ethanol. Microbial evolution was measured with culture-dependent and molecular approaches. Then, a native isolated Candida oleophila was selected for further sequential fermentations with Saccharomyces cerevisiae. The grape cultivars in the Maule showed a diversity of non-Saccharomyces yeasts, with a greater diversity observed at the beginning of the fermentation. However, species from the Hansenasporia, Metschnikowia, Torulaspora, Lachancea, and Candida genera were detected after 7 days, suggesting tolerance to environments rich in ethanol, capability may be associated to the terroir studied, which is characterized by torrid weather and antique and traditional vineyards. The alcoholic fermentation negatively impacted the LAB population, and after 7 days only Leuconostoc mesenteroides was isolated. In the sequential fermentations, C. oleophila was able to produce fermented grape juices with <1.5 g/L glucose, 12.5% (v/v) alcohol, and low concentrations of malic (<1.00 g/L) and succinic (2.05 g/L) acids, while acetic acid reached values >0.3 (g/L). To our knowledge this is the first time C. oleophila has been reported as a potential starter culture for wine production. However, more studies are necessary to fully characterize the potential of C. oleophila on wine attributes.

The study of non-Saccharomyces yeasts in wine fermentations allows the exploration of new alternatives for the reduction of ethanol in wines. The objective of this work was to evaluate the fermentation capacity of two indigenous Candida yeasts (C. oleophila and C. boidinii) in monoculture and sequential fermentations (laboratory and microvinification scale) to produce Chilean Sauvignon Blanc wine. Fermentations were monitored by the determination of ethanol, glycerol, organic acids, and residual sugars. The results indicated that at the laboratory scale for both the monoculture and sequential fermentations it was possible to reduce the ethanol concentration on 0.77% v/v (monoculture) and 1.5% v/v (sequential) for C. oleophila and 0.50% v/v (monoculture) and 0.04% v/v (sequential) for C. boidinii compared to S. cerevisiae (12.87% v/v). Higher glycerol concentrations were produced in monoculture than sequential fermentations (C. oleophila: 9.47 g/L and C. boidinii 10.97 g/L). For microvinifications, the monoculture and sequential fermentations with C. boidinii managed to reduce ethanol content by 0.17% v/v and 0.54% v/v, respectively, over the S. cerevisiae control (13.74% v/v). In the case of C. oleophila, the reduction was only observed in sequential fermentations with 0.62% v/v. Interestingly, grapes with higher sugar concentration resulted in wines with lees ethanol concentrations. This might be associated to the use of C. oleophila (13.12% v/v) and C. boidinii (13.20% v/v) in sequential fermentations microvinification scale.

Organic nitrogen plays a significant role in the fermentation performance and production of esters and higher alcohols. This study assessed the use of yeast protein hydrolysate (YPH) as a nitrogen source for grape must fermentation. In this study, we prepared an enzymatic protein hydrolysate using yeasts recovered from a previous fermentation of wine. Three treatments were performed. DAP supplementation was used as a control, while two YPH treatments were used. Low (LDH) and high degrees of hydrolysis (HDH), 3.5% and 10%, respectively, were chosen. Gas chromatography and principal component analysis indicated a significant positive influence of YPH-supplementations on the production of esters and higher alcohols. Significantly high concentrations of 3-methyl-1-penthanol, isoamyl alcohol, isobutanol, and 2-phenylethanol were observed. Significant odorant activity was obtained for 3-methyl-1-pentanol and ethyl-2-hexenoate. The use of YPH as nitrogen supplementation is justified as a recycling yeasts technique by the increase in volatile compounds.

The seed from the Araucaria araucana (in Spanish, piñon) tree, native to Chile and Argentina, is sold mainly as raw seed. Engineering a process to add value to piñon has the potential to positively impact local indigenous communities with very little ecological impact because it is routinely harvested in the wild. This study evaluated the feasibility of using 100% piñon, or as a blend with barley malt, to produce a beer-like beverage, while also evaluating consumer acceptance of the beverage’s piñon characteristics. Prototypes generated based on 93% piñon and 7% oat (enzymatic treatment of α-amylase, glucoamylase, protease and β-glucanase), as well as 50% piñon and 50% barley (no external enzymatic treatment), were evaluated. Overall acceptability by a consumer acceptance panel (21 consumers) rated the 100% piñon and the piñon–barley malt blend 5/9 and 7/9, respectively. The piñon–barley malt blend prototype stood out for its low level of carbohydrates, high potassium content and banana and clove aromas.

In Chile, there are several abandoned mine tailing impoundments near population centers that need to be remediated. In this study, the ability of Oxalis gigantea, Cistanthe grandiflora, and Puya berteroniana to remove Zn, Ni, and Cr from mine tailings was evaluated. The plants’ removal efficiency, bioconcentration, and translocation factors regarding these metals were determined to assess the ability of certain endemic species from Northern and Central Chile to extract or stabilize metals. After a period of seven months, the chemical analysis of plants and tailings, together with the statistical treatment of data, indicated the inability of all the species to translocate Ni, Cr, or Zn with a translocation factor lower than one. The results showed the stabilizing character of Oxalis gigantea, Puya berteroniana, and Cistanthe grandiflora for Zn, with a bioconcentration factor close to 1.2 in all cases, and the same ability of the latter two species for Cr, with a bioconcentration factor of 1.5 in the case of Cistanthe grandiflora and 1.7 for Puya berteroniana. Finally, a removal efficiency of 9.3% was obtained with Cistanthe grandiflora for Cr and 15% for Ni; values lower than 6.4% were obtained for Zn in all cases. Improvements in the process should be sought to enhance the performance of these species for the accumulation of the target metals.

En este estudio se caracterizó la microbiota natural (levaduras y bacterias ácido lácticas) observada durante la fermentación espontánea de variedades de uva de Chile, con el fin de evaluar su potencial para producir vinos con menor contenido de etanol. El potencial de fermentación de las levaduras seleccionadas se determinó en términos de consumo de azúcar y producción de etanol. Las cepas con potencial para producir vinos reducidos en etanol se estudiaron adicionalmente en inoculaciones secuenciales con Saccharomyces cerevisiae. Se identificaron nueve especies no Saccharomyces y solo tres géneros de bacterias ácido lácticas. Durante las etapas finales de fermentación, S. cerevisiae y L. mesenteroides fueron dominantes, mientras que solo Candida, Metchnikowia, Torulaspora y Lachancea spp. se observaron después de 14 días de fermentación. La fermentación de cultivo puro con cepas aisladas seleccionadas mostró aproximadamente un 50% de utilización de azúcar, con una producción de etanol que varió desde 6.25 a 9.25% v/v. Nuestros resultados sugieren que las levaduras nativas R. glutinis, M. pulcherrima y H. uvarum, aisladas en este estudio, son potenciales para producir vinos reducido en etanol. Sin embargo, se necesitan más estudios sobre la contribución en sabor y el aroma.